‘dixie verse gy TECH TIPS Dixie Part Numbers: TBA Applications: 2009 Chevrolet Aveo 2009 Pontiac G3 2009 Pontiac Wave (Canadian Models) Condition: The operator of the vehicle may complain that on an intermittent basis the engine will not crank or start when the key is turned to the start position and that the service engine light is on. The technician may observe one or more of the following diagnostic trouble codes stored in the system: – P0604 – P0606 – P16F3 Cause: There are several possible causes for the above condition including but not limited to: – an outdated calibration file in the engine control module – anincorrectly positioned transmission gear selector lever – loose or poor grounds at the following locations: – G101 behind the right headlight – G102 behind the left headlight left of the battery – G103 below the ECM – G104 beside the starter motor – G401 under the rear luggage shelf on the left side – alow or faulty battery – apoorly connected factory installed anti-theft system – adamaged ignition switch – a faulty engine control module – aninstrument cluster with a quiescent draw of more then 100 mA – aninstrument cluster that intermittently drops to zero with the engine running – a failed smart junction block Correction: Follow the manufacturer’s recommended troubleshooting and repair procedures. REV: 20100607 Courtesy of APRA TSB_157.doc Dixie Tech Tips are intended for use by professional technicians, and are not for the general public. They are written to inform technicians of conditions that may exist or as a guide to aid in diagnosing and servicing a vehicle. All references to original equipment manufactures, vehicle manufactures and any other Trade Mark names are for the sole purpose of identifying the vehicle and or part that the Tech Tip applies to. This document is property of Dixie Electric Ltd. and is not to be copied or distributed with out written permission.